18 years back and many miles since, I replaced the Factory original Mode Actuator and heater core. Well, a couple of weeks back the replacement Mode Actuator failed. I ordered a new Actuator from Old Air Products. I figured even though the Heater core was still good, not leaking, I might as well replace it while I had everything apart. I ordered the new heater core from Rock Auto. I have the Heater Box assembled but I haven't installed it under the dash, yet. For anyone interested, I uploaded to my page, some pictures of the Heater Box, etc. I was able to remove the Heater Box from under the dash without removing the blower housing from the engine bay firewall or removing the hood hinge, as the shop manual lists to do.

Views: 209

Reply to This

Replies to This Discussion

You can JB weld that resistor together.   To fix the vacuum valve, drill the rivet head off and sand the 2 sealing surfaces flat again. Use a mirror with fine sandpaper. The mirror will give you a flat surface.

You will need to drill and tap the rivet post for a machine screw. Use Loctite so the screw doesn't back out. 

I have extra valves if you screw it up. 

Russ, Thanks for the tip!

Forgot to mention that you will need to use high temp vacuum grease between the 2 halves.

Russ, thanks for the follow up on the required lubricant. 

RSS

Photos

  • Add Photos
  • View All

Forum

Free 1964 parts before I throw them out

Started by Preston Bealle in 1963/64 Cadillac Specific Discussion. Last reply by Preston Bealle 7 hours ago. 6 Replies

I have front brake drums and discs, a window, a window frame, and an air cleaner shroud. I don't need them and anyone can have them for shipping cost. I would guess the shipping would be $20-25 for…Continue

Winter time cruise in Australia.

Started by Kevin Campbell in General Discussion. Last reply by mike page 8 hours ago. 1 Reply

The weather here in winter is great for a Cadillac cruise.Continue

Current 1963/64 Cadillac Listings on eBay

Started by Jason Edge in For Sale. Last reply by Jason Edge 8 hours ago. 0 Replies

To see all 1963/64 Cadillacs Listed on eBay in the USA…Continue

Tags: ebay

Limited slip differential gear set for sale.

Started by Russ Austin in General Discussion. Last reply by Russ Austin 12 hours ago. 2 Replies

I have a limited slip differential gearset for sale. 2.94 gears and it came out of my car so I know it is good. Fits 59 to 64. For the 59-62, you will need to put your yoke on, as it is different…Continue

Blog Posts

64 Power Servo vacuum leak

Posted by Kent Prows on June 27, 2020 at 4:02pm 0 Comments

I finally got around to fixing a leak in my heater core.  I decided to check to see if there were any other obvious issues while I had everything torn apart.  When I put a vacuum directly (bypassing the transducer) to the power servo it gets to about 10" and then slowly leaks back to zero.  The fan will not go to full and the mode door will not open completely.  I have read a couple of other posts that said they repaired the power servo leaks.  How?  Does anyone have one to sell?  I just…

Continue

63 Caddy Horn

Posted by Robert Alan Shannon on May 27, 2020 at 9:25am 9 Comments

 Just noticed a 1963  Caddy trumpet horn on Ebay. No part # given but some of his other items are 1963 specific, just throwin this out there, I have no connection to this listing .

Wiring connection help.

Posted by Jimmy Davis on May 24, 2020 at 9:15pm 2 Comments

Can someone help me figure where these connections go? I have a 64 60 special if it matters.…



Continue

Wood grain finally done.

Posted by Jimmy Davis on May 20, 2020 at 4:57pm 3 Comments

After years of wanting to, I finally redid my wood dash paneling on my 64 60s. Not too hard to do either.…

Continue

Events

Videos

  • Add Videos
  • View All

© 2020   Created by Jason Edge.   Powered by

Badges  |  Report an Issue  |  Terms of Service