Just finished dropping the tank on the 63 SDV due to the common problem of gas smell when I filled it up. It was either due to a bad gasket on sender or cracked hose on vent tube. Project cost me 40.00. Ingredients were as follows:
3ft. 1/4 fuel line for return line
3ft 5/16 fuel line for fuel line
7 Inches of 2 inch filler hose
2 inches of 5/8 vent tube hose
Clamps for lines
Gasket material for sender unit
Fuel sender sock
Everything was pretty straight forward on removal and install. Just a lot of time laying on your back on cold concrete getting dirt in your eyes. I had even tried to wash the underside off but living on rural gravel roads you can never get it all.
Pretty much followed Jason'.s pics on supporting the rear end, etc. Thanks Jason. Didn't do any painting as this is a driver. Maybe a project for summertime. I did find out that the straps go on much easier with the J on the Jbolts facing the front of the car. Also, replace the fuel sock! Mine looked ok when I pulled the sender but when I turned it over, it was split apart so it wasn't doing much filtering.
And, so far, NO MORE SMELL!
Thanks all for the guidance from this site
Tom B
Comment
Great job Tom and good advice Robert. Only thing I can add is also keep a big bottle of saline eye wash in the garage for those times that you get in too big of a hurry and think you can slide under the car, and touch anything over head and not get something in your eyes! :-)
Did this project a few years back for the same reason, gas smell. Also found my fuel sock split open. Also my fuel gauge would peg out to full with the tank empty. That small copper strap had broken so soldered it back together. Fixed fuel gauge problem. I 've learned the hard way to wear eye protection while under the car, that debris will get in the eyes.
Started by Logan Robb in 1963/64 Cadillac Specific Discussion. Last reply by Logan Robb 2 minutes ago. 3 Replies 0 Likes
I noticed this issue at the end of last summer/fall, but it seems to be getting worse as I have begun driving for the season again. When I drive the car and get everything good and warmed up, if I…Continue
Started by Jason Edge in General Discussion. Last reply by Logan Robb yesterday. 3 Replies 0 Likes
I recently picked up a rather large batch of parts from a contact that has sold their 63 and had left over parts. Here was one item I pulled that make me smile - a 1963 Indiana License Plate. For…Continue
Started by Jeff Donaldson in General Discussion. Last reply by Jeff Donaldson yesterday. 3 Replies 0 Likes
Has anyone bought new oem headlights from Lectric Limited? They want $150 for a set of new remanufactured ones. Any advice would be appreciated.JeffContinue
Posted by Dave Fehrle on March 23, 2024 at 3:23pm 8 Comments 0 Likes
While checking my Carter carb with engine running, I took the air cleaner off and there was a very loud hissing sound of air. I placed a piece of paper over the carb and it didn’t move up or down, is this normal?
Posted by Chase on March 21, 2024 at 5:55am 0 Comments 1 Like
Hey everyone, has anybody done a Vintage Air AC/Heat setup in their car? I want to bypass the old vacuum setup and go with a Vintage Air Gen 2 model. Before I get started, does anyone have any experience with this? (Which model to go with, do’s and dont’s, etc.) It looks pretty involved. Any and all info/pics would be greatly appreciated. Thanks!
Posted by CHRIS CARLSON on December 6, 2023 at 10:54am 0 Comments 0 Likes
Who rebuilds original AC accumulator dryers for 1964 Cadillac? I have been on Classic auto air in Tampa FL wait list for over a year , There is one on Old air products web site that looks very similar to the original # 21-4214A but states it fits 1962 Gm cars, The one recommended for a 1964 Cadillac is half the length 21-4215A What is everyone using ? I would prefer to be as original as possible. Thanks
Posted by Les Eastling on November 15, 2023 at 10:34am 1 Comment 0 Likes
My son, unbeknownst to me, had all three of the horns on our 1963 Eldorado completely restored. We had recently added the Eldorado trumpet horn to the two standard horns and the sound was not very good... we had heard good ones so we knew something was not right... but there was not much we could do to get better sound from the 3 horns.
There is a restoration service called The Horn Works who my son…
Continue© 2024 Created by Jason Edge. Powered by
You need to be a member of 63/64 Cadillac Website to add comments!
Join 63/64 Cadillac Website