18 years back and many miles since, I replaced the Factory original Mode Actuator and heater core. Well, a couple of weeks back the replacement Mode Actuator failed. I ordered a new Actuator from Old Air Products. I figured even though the Heater core was still good, not leaking, I might as well replace it while I had everything apart. I ordered the new heater core from Rock Auto. I have the Heater Box assembled but I haven't installed it under the dash, yet. For anyone interested, I uploaded to my page, some pictures of the Heater Box, etc. I was able to remove the Heater Box from under the dash without removing the blower housing from the engine bay firewall or removing the hood hinge, as the shop manual lists to do.

Views: 219

Reply to This

Replies to This Discussion

You can JB weld that resistor together.   To fix the vacuum valve, drill the rivet head off and sand the 2 sealing surfaces flat again. Use a mirror with fine sandpaper. The mirror will give you a flat surface.

You will need to drill and tap the rivet post for a machine screw. Use Loctite so the screw doesn't back out. 

I have extra valves if you screw it up. 

Russ, Thanks for the tip!

Forgot to mention that you will need to use high temp vacuum grease between the 2 halves.

Russ, thanks for the follow up on the required lubricant. 

RSS

Photos

  • Add Photos
  • View All

Forum

Door jamb switches

Started by Jay Waters in 1963/64 Cadillac Specific Discussion. Last reply by Charles Fares 5 hours ago. 4 Replies

Anyone have a good set of door jamb courtesy light switches ? 2 or 4.What does the trunk light operate from ?Continue

wanted, '64 tilt turn signal switch WITH cornering contacts.

Started by john kilbourne in Wanted to Buy. Last reply by john kilbourne 15 hours ago. 2 Replies

I have the regulra one.Continue

Current 1963/64 Cadillac Listings on eBay

Started by Jason Edge in For Sale. Last reply by Jason Edge 16 hours ago. 0 Replies

To see all 1963/64 Cadillacs Listed on eBay in the USA…Continue

Tags: ebay

Blog Posts

Website

Posted by Fritz Seitz on August 11, 2020 at 2:35am 0 Comments

I have been working on a website-----www.fritzsautorepair.com-----

Does anyone have suggestions?

Electrical

Posted by Anthony Boles on August 8, 2020 at 5:46pm 5 Comments

My 1964 Cadillac electrical system is running around 17 volt which is to high,the alternator, battery and the voltage regulator was replaced but the voltage is still to high, could it be the pig tail that plugs into the voltage regulator. 

63 Caddy Horn

Posted by Robert Alan Shannon on May 27, 2020 at 9:25am 10 Comments

 Just noticed a 1963  Caddy trumpet horn on Ebay. No part # given but some of his other items are 1963 specific, just throwin this out there, I have no connection to this listing .

Wiring connection help.

Posted by Jimmy Davis on May 24, 2020 at 9:15pm 2 Comments

Can someone help me figure where these connections go? I have a 64 60 special if it matters.…



Continue

Events

Videos

  • Add Videos
  • View All

© 2020   Created by Jason Edge.   Powered by

Badges  |  Report an Issue  |  Terms of Service